|
STATE OF
INDIANA |
) |
|
BEFORE THE
INDIANA DEPARTMENT |
||
|
|
|||||
|
COMMISSIONER
OF THE DEPARTMENT Complainant, v. SHILOH DIE
CAST MIDWEST, LLC, PIERCETON PLANT, Respondent. |
) |
|
|||
AGREED
ORDER
Complainant
and Respondent desire to settle and compromise this action without hearing or
adjudication of any issue of fact or law, and consent to the entry of the
following Findings of Fact and Order.
Pursuant to IC 13-30-3-3, entry into the terms of this Agreed Order does
not constitute an admission of any violation contained herein. Respondent's entry into this Agreed Order
shall not constitute a waiver of any defense, legal or equitable, which
Respondent may have in any future administrative or judicial proceeding, except
a proceeding to enforce this order.
I. FINDINGS OF FACT
1.
Complainant is the Commissioner (“Complainant”)
of the Indiana Department of Environmental Management (“IDEM”), a department of
the State of Indiana created by Indiana Code (“IC”) 13-13-1-1.
2.
Respondent is Shiloh Die Cast Midwest, LLC,
Pierceton Plant (“Respondent”), which owns and operates the source with Plant
ID No. 085-00079 located at 5 Arnolt Drive in Pierceton,
Kosciusko County, Indiana (“Site”).
3.
IDEM has jurisdiction over the parties and the subject
matter of this action.
4.
Pursuant to IC 13-30-3-3, IDEM issued a Notice
of Violation (“NOV”) via Certified Mail to:
|
Shiloh
Die Cast, LLC, Member |
Corporation
Service Company, |
|
Shiloh
Die Cast Midwest, LLC |
Registered
Agent |
|
880
Steel Dr |
Shiloh
Die Cast Midwest, LLC |
|
Valley
City, OH 44280 |
135
N Pennsylvania St, Suite 1610 |
|
|
Indianapolis,
IN 46204 |
5.
Respondent owns and operates a stationary
aluminum die-casting plant, using clean charge only.
6.
During a review of stack testing reports
conducted by a representative of IDEM, the following violations were found:
a. Pursuant to Federally Enforceable State
Operating Permit No. 085-33582-00079 (“Permit”)
Condition D.1.1, particulate matter (“PM”) emissions from the shot blasting
unit EU2 shall not exceed 0.19 pounds per hour.
During the stack test on August 23, 2017, Respondent’s PM emissions from the
shot blasting unit EU2 were 0.59 pounds per hour, in violation of Permit
Condition D.1.1.
b. Pursuant to Permit Condition D.1.7,
Respondent is responsible for performing PM, PM10, and PM2.5 testing on the
shot blasting unit at least once every five (5) years from the last valid
compliance demonstration.
Respondent failed to perform PM10 and
PM2.5 testing on the shot blasting unit by September 27, 2017, five (5) years
from the last valid test, in violation of Permit Condition D.1.7.
7.
Respondent re-tested in compliance for PM,
PM10, and PM2.5 on November 28, 2017.
8.
In recognition of the settlement reached,
Respondent waives any right to administrative and judicial review of this
Agreed Order.
II. ORDER
1.
This Agreed Order shall be effective
(“Effective Date”) when it is approved by Complainant or Complainant’s
delegate, and has been received by Respondent.
This Agreed Order shall have no force or effect until the Effective
Date.
2.
Respondent shall comply with Permit Conditions
D.1.1, D.1.7, and all other conditions of its current applicable permit.
3.
All submittals required by this Agreed Order,
unless Respondent is notified otherwise in writing by IDEM, shall be sent to:
|
Clare Parker, Case Manager |
|
Compliance and Enforcement Branch –
Mail Code 61-53 |
|
Indiana Department of Environmental
Management |
|
100 North Senate Avenue |
|
Indianapolis, IN 46204-2251 |
4.
Respondent is assessed and agrees to pay a
civil penalty of Eight Thousand Five Hundred Dollars ($8,500.00). Said
penalty amount shall be due and payable to the Environmental Management Special
Fund within thirty (30) days of the Effective Date; the 30th day
being the “Due Date”.
5.
Civil penalties are payable by check to the
“Environmental Management Special Fund.” Checks shall include the Case Number of this
action and shall be mailed to:
|
IDEM
Office of Legal Counsel |
|
IGCN,
Rm N1307 |
|
100
N Senate Ave |
|
Indianapolis,
IN 46204 |
6.
This Agreed Order shall apply to and be binding
upon Respondent and its successors and assigns.
Respondent’s signatories to this Agreed Order certify that they are
fully authorized to execute this Agreed Order and legally bind the party they
represent. No change in ownership,
corporate, or partnership status of Respondent shall in any way alter its status
or responsibilities under this Agreed Order.
7.
In the event that the monies due to IDEM
pursuant to this Agreed Order are not paid on or before their Due Date,
Respondent shall pay interest on the unpaid balance at the rate established by
IC 24-4.6-1. The interest shall be
computed as having accrued from the Due Date until the date that Respondent
pays any unpaid balance. Such interest
shall be payable to the Environmental Management Special Fund, and shall be
payable to IDEM in the manner specified in Paragraph 5, above.
8.
In the event that any terms of this Agreed
Order are found to be invalid, the remaining terms shall remain in full force
and effect and shall be construed and enforced as if this Agreed Order did not
contain the invalid terms.
9.
Respondent shall provide a copy of this Agreed
Order, if in force, to any subsequent owners or successors before ownership
rights are transferred. Respondent shall ensure that all
contractors, firms and other persons performing work under this Agreed Order
comply with the terms of this Agreed Order.
10.
This Agreed Order is not and shall not be
interpreted to be a permit or a modification of an existing permit. This Agreed Order, and IDEM’s review or
approval of any submittal made by Respondent pursuant to this Agreed Order,
shall not in any way relieve Respondent of its obligation to comply with the
requirements of its applicable permits or any applicable Federal or State law
or regulation.
11.
Complainant does not, by its approval of this
Agreed Order, warrant or aver in any manner that Respondent’s compliance with
any aspect of this Agreed Order will result in compliance with the provisions
of any permit, order, or any applicable Federal or State law or
regulation. Additionally, IDEM or anyone
acting on its behalf shall not be held liable for any costs or penalties
Respondent may incur as a result of Respondent’s efforts to comply with this
Agreed Order.
12.
Nothing in this Agreed Order shall prevent or
limit IDEM’s rights to obtain penalties or injunctive relief under any
applicable Federal or State law or regulation, except that IDEM may not, and
hereby waives its right to, seek additional civil penalties for the same violations
specified in the NOV.
13.
Nothing in this Agreed Order shall prevent IDEM
or anyone acting on its behalf from communicating with the EPA or any other
agency or entity about any matters relating to this enforcement action. IDEM or anyone acting on its behalf shall not
be held liable for any costs or penalties Respondent may incur as a result of
such communications with the EPA or any other agency or entity.
14.
This Agreed Order shall remain in effect until
Respondent has complied with all terms and conditions of this Agreed Order and IDEM
has issued a Resolution of Case letter to Respondent.
|
TECHNICAL
RECOMMENDATION: |
|
RESPONDENT: |
|||||
|
Department
of Environmental Management |
|
Shiloh
Die Cast Midwest, LLC, Pierceton Plant |
|||||
|
|
|
|
|||||
|
By: |
|
|
By: |
|
|||
|
|
David
P. McIver, Chief |
|
Printed: |
|
|||
|
|
Enforcement
Section |
|
Title: |
|
|||
|
|
Office
of Air Quality |
|
|
|
|||
|
Date: |
|
|
Date: |
|
|||
|
|
|
|
|
|
|||
|
|
|
|
|||||
|
|
|
COUNSEL
FOR RESPONDENT: |
|||||
|
|
|
|
|||||
|
|
|
|
|||||
|
|
|
|
By: |
|
|||
|
|
|
|
|
|
|||
|
|
|
|
|
|
|||
|
|
|
|
Date: |
|
|||
|
|
|
|
|
|
|||
|
APPROVED
AND ADOPTED BY THE INDIANA DEPARTMENT OF ENVIRONMENTAL |
|||||||
|
MANAGEMENT THIS |
|
DAY OF |
|
,
2019. |
|||
|
|
|||||||
|
|
For
the Commissioner |
||||||
|
|
|
||||||
|
|
Signed
on February 27, 2019 |
||||||
|
|
Matthew
Stuckey, Deputy Assistant Commissioner |
||||||
|
|
Office
of Air Quality |
||||||
|
|
Indiana
Department of Environmental Management |
||||||